View MO15ETFT-LCD_2991143.PDF datasheet online --- IC-ON-LINE

Datasheet File OCR Text:

tft-lcd monitor mo15e* manual service tft-lcd monitor contents 1. precautions 2. product specifications 3. disassembly & reassembly 4. troubleshooting 5. exploded view & parts list 6. electrical parts list 7. block diagram 8. wiring diagram 9. schematic diagrams 10. panel description confidential
1-1-1 warnings 1. for continued safety, do not attempt to modify the circuit board. 2. disconnect the ac power and dc power jack before servicing. 3. when the chassis is operating, semiconductor heatsinks are potential shock hazards. 1-1-2 servicing the lcd monitor 1. when servicing the lcd monitor, remove the static charge by connecting a 10k ohm resistor in series with an insulated wire (such as a test probe) between the chassis and the anode lead. (disconnect the ac line cord from the ac outlet.) 2. it is essential that service technicians have an accurate voltage meter available at all times. check the calibration of this meter periodically. 1-1-3 fire and shock hazard before returning the monitor to the user, perform the following safety checks: 1. inspect each lead dress to make certain that the leads are not pinched or that hardware is not lodged between the chassis and other metal parts in the monitor. 2. inspect all protective devices such as nonmetallic control knobs, insulating materials, cabinet backs, adjustment and compartment covers or shields, isolation resistor-capacitor networks, mechanical insulators, etc. 3. leakage current hot check (figure 1-1): warning: do not use an isolation transformer during this test. use a leakage current tester or a metering system that complies with american national standards institute ( ansi c101.1, leakage current for appliances ), and underwriters laboratories ( ul publication ul1410, 59.7 ). figure 1-1. leakage current test circuit 4. with the unit completely reassembled, plug the ac line cord directly into a 120v ac outlet. with the unit? ac switch first in the on position and then off, measure the current between a known earth ground (metal water pipe, conduit, etc.) and all exposed metal parts, including: metal cabinets, screwheads and control shafts. the current measured should not exceed 0.5 milliamp. reverse the power-plug prongs in the ac outlet and repeat the test. 1-1-4 product safety notices some electrical and mechanical parts have special safety-related characteristics which are often not evident from visual inspection. the protection they give may not be obtained by replacing them with components rated for higher voltage, wattage, etc. parts that have special safety characteristics are identified by on schematics and parts lists. a substitute replacement that does not have the same safety characteristics as the recommended replacement part might create shock, fire and / or other hazards. product safety is under review continuously and new instructions are issued whenever appropriate. mo15e* 1-1 confidential 1 precautions follow these safety, servicing and esd precautions to prevent damage and to protect against potential hazards such as electrical shock. 1-1 safety precautions device under test test all exposed metal surfaces (reading should not be above 0.5ma) leakage current tester 2-wire cord also test with plug reversed (using ac adapter plug as required) earth ground !
confidential 2 product specifications 2-1 specifications lcd panel tft-lcd panel, rgb vertical stripe, normaly white, 15-inch viewable, 0.297 mm pixel pitch scanning frequency horizontal : 31 khz ~ 60 khz (automatic) vertical : 56 hz ~ 75 hz (automatic) display colors 16.2 m maximum resolution horizontal : 1024 pixels vertical : 768 pixels input video signal analog, 0.7 vp-p 1% positive at 75 ? , internally terminated input sync signal type : seperate h/v sync, composite h/v, sync-on-green, automatic synchronization without external switch of sync type level :ttl level maximum pixel clock rate 80 mhz active display horizontal/vertical 304.1 mm / 228.1 mm ac power voltage & frequency ac 90 ~ 264 volts, 60/50 hz ~ 12 v/3 a power consumption 30 w (max) dimensions / unit weight / incl.carton unit (w x d x h) 357.5 x 184.5 x 360.6 mm (14.1 x 7.3 x 14.2 inches) carton (w x d x h) 440 x 363 x 145 mm (17.3 x 14.3 x 5.7 inches) weight (net/gross) normal stand 2.9 kg (6.4 lbs) / 4.6 kg (10.1 lbs) multi stand 2.98 kg (6.6 lbs) / 4.68 kg (10.3 lbs) environmental considerations operating temperature : 50 ? ~ 104 ? (10 ? ~ 40 ?) humidity : 10 % ~ 80 % storage temperature : 13 ? to 113 ? (-25 ? ~ 45 ?) humidity : 5 % ~ 95 % ?o15e* complies with swedac (mpr ii) recommendations for reduced electromagnetic fields. ?esigns and specifications are subject to change without prior notice. mo15e* 2-1 item description
1. locate the monitor on the table with face down. 2. loose the snaps of hinge cap through the slot of cover rear. 3. remove the hinge cap. confidential mo15e* 3-1 3 disassembly and reassembly this section of the service manual describes the disassembly and reassembly procedures for the mo15e* monitors. warning: this monitor contains electrostatically sensitive devices. use caution when handling these components. 3-1 disassembly cautions: 1. disconnect the monitor from the power source before disassembly. 2. follow these directions carefully; never use metal instruments to pry apart the cabinet. 3-1-1 main body disassembly
confidential mo15e* 4-1 4 troubleshooting notes: 1. before troubleshooting, setup the pc?s display as below. resolution: 1024 x 768 h-frequency: 48 khz v-frequency: 60 hz 2. if no picture appears, make sure the power cord is correctly connected. 3. check the following circuits. no raster appears: smps pcb, main pcb 14v develop but no screen: main pcb 14v does not develop: smps pcb 4. if you push and hold the exit button for more than 5 seconds, the monitor automatically turns back to the factory preset. 4-1 no power does proper dc 14 v appear at pin 1, 2 or pin 3 of cn202? check smps. yes no does proper dc 3.3 v appear at pin 4 of ic100? check ic100. check ic101, ic301, ic500 or ic602. yes no
mo15e* 5-1 confidential 5 exploded view and parts list
confidential mo15e* 6-1 - bn94-00302a assy pcb main mo15es sna cis bh73-60304e rubber-support mo15ps,cr v0,6*6*6.4,black sna cis bn39-00002a cbf-harness -,60,blu/wht,-,26,- sna cis bn39-00251a lead connector assy mo15es,ul1571#30,ul/csa,20p,#30,12507hs-20,12507hs-20,bk,40mm,1571#30,sj01-01-33 cis bn44-00066a inverter mo15ps,sic581,48khz,14vdc,2.6marms,6.1marms,48khz,140*50*8.0,4lamp cis bn70-00264a plate-brkt ground mo15ps,secc,-,t0.8,-,-,-,-,mo15ps sna cis bn72-00307a plate-pcb mo15ps,abs+pc,iv16,-,-,5v,-,-,- sna cis6 bn63-00265a gasket mo15ps,conductive fablic,4mm,10mm,17mm,gray,71tssk 10-4-17-13,71tssk 10-4-17-13 sna cis7 bn63-00266a gasket mo15ps,conductive fablic,4mm,4mm,60mm,gray,71ttsk 4-4-60-13,71ttsk 4-4-60-13 sna sh/mo+br/gr+pcb 6001-001340 screw-machine ch,+,m2.0,l4.5,zpc(yel),swrch18a,fp - bn97-00094a assy smd mo15es sna c100 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c101 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c102 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c103 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c104 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c105 2203-001652 c-ceramic,chip 470nf,+80-20%,16v,y5v,tp,1608 c106 2203-001652 c-ceramic,chip 470nf,+80-20%,16v,y5v,tp,1608 c107 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c200 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c201 2203-000189 c-ceramic,chip 100nf,+80-20%,25v,y5v,tp,1608, c202 2203-000236 c-ceramic,chip 0.1nf,5%,50v,np0,tp,1608 c203 2203-000236 c-ceramic,chip 0.1nf,5%,50v,np0,tp,1608 c204 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c205 2203-000815 c-ceramic,chip 0.033nf,5%,50v,np0,tp,1608 c206 2203-000626 c-ceramic,chip 0.022nf,5%,50v,np0,tp,1608 c208 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c210 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c212 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c213 2203-000384 c-ceramic,chip 0.015nf,5%,50v,np0,tp,1608 c214 2203-000384 c-ceramic,chip 0.015nf,5%,50v,np0,tp,1608 c215 2203-000384 c-ceramic,chip 0.015nf,5%,50v,np0,tp,1608 c216 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c217 2402-000108 c-al,smd 10uf,20%,16v,wt,tp,4.3x4.3x5.4 c218 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c219 2203-000257 c-ceramic,chip 10nf,10%,50v,x7r,tp,1608 c220 2402-000108 c-al,smd 10uf,20%,16v,wt,tp,4.3x4.3x5.4 c300 2402-000135 c-al,smd 22uf,20%,16v,gp,tp,5.3x5.3x5.4 c301 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c302 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c303 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c304 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c305 2402-000135 c-al,smd 22uf,20%,16v,gp,tp,5.3x5.3x5.4 c306 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c307 2402-000135 c-al,smd 22uf,20%,16v,gp,tp,5.3x5.3x5.4 c308 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c309 2203-000041 c-ceramic,chip 0.01nf,0.25pf,50v,np0,tp,1608 c310 2203-000843 c-ceramic,chip 39nf,10%,25v,x7r,tp,1608,- loc. no. code no. description specification remarks 6 electrical parts list 6-1 main pcb parts
7 block diagram mo15e* 7-1 h v nt7181f brightness on/off +14v 12mhz 12mhz (mascot v) confidential
8 wiring diagram mo15e* 8-1 confidential 8 wiring diagram
confidential mo15e* 9-1 9 schematic diagrams 9-1 schematic diagram 100nf r523 100 g-gnd g-video b-video b-gnd v-sync +14vdc r-gnd dsub_+5v dsub_sda dsub_scl r-video chk_dsub dsub_gnd h-sync p-gnd d202 bzx84c5v1 1 2 3 16v 100uf c107 75 r216 c703 470nf 16v mo c105 470nf 16v mo b c e 4.7k r520 +5v ksc1623-y q601 r215 33 1/16w r213 c101 mo 100nf 16v 75 mo 16v 470nf c106 l200 1.5uh d204 mmbd4148se 1 2 3 ms_3.3v r525 100 +5v 8 sk34 d100 slcon8p 1 2 3 4 5 6 7 470nf 16v cn501 100uf c705 c501 ms_3.3v c500 100nf 16v r206 100 1/16w c206 22pf r200 1/16w 10k r218 680k 10 r100 1/16w 4.7k r527 r208 16v 470nf c513 mo 0 c509 50v 470nf 16v mo 50v 15pf c511 c512 15pf e c220 10uf q701 ksc1623-y b c c601 100nf r220 4.7k 1/16w 1/16w 33 r209 16v 100nf c702 100 1/16w r207 d203 1 2 3 10 r211 100 1/16w mmbd4148se c706 100uf 16v r606 vin 16v 100uf c701 4 f_b 3 gnd 6 gnd1 on_off 5 out 2 1 r508 18k ic100 lm2596s-3.3 18k r509 +5v 100uf 16v c502 8 c504 16v 100uf slcon8p cn600 1 2 3 4 5 6 7 100nf c210 d1_1 7 6 d2 d2_1 5 2 g1 4 g2 s1 1 s2 3 +5v 1 a 2 b si9933ady-t1 ic101 8 d1 blm41p600s ft701 1.5uh l601 47k 1/16w r201 r212 1/16w 33 r605 510 1/16w c215 15pf 50v q600 ksc1623-y b c e 100nf c505 16v 100 100nf c503 16v tp1491 1 r515 r514 0 r702 100 1/16w r501 10k 1/16w 53uh l101 r203 1/16w 100 100nf c208 c213 15pf 50v panel_3.3v 75 r210 2 gnd 1 in 3 out c600 100nf 16v 470nf c704 ic500 ba17805fp 10k r101 r102 tp1490 1 10k r5134.7k 100 r516 r502 470 r500 r503 100 r506 100 4.7k 100 0 r519 10 r701 r217 r700 4.7k 1/16w +3.3v 100 r521 100pf c203 100 r507 +5v r526 100 c508 10uf r518 1k r512 r5114.7k r517 4.7k a 2 c1 6 c2 4 c3 3 c4 1 nc 5 100 a 6 c1 4 c2 3 c3 1 c4 5 nc qzx363c5v6 ic601 ic200 qzx363c5v6 2 +5v r204 100 1/16w mmbd4148se 1 2 3 c218 +5v d205 r524 100 c507 22pf 1/16w 1m c506 22pf x501 hc-49/s-smd(12mhz,30ppm) q0 q1 r505 c212 100nf 50v 15pf c214 r703 10k 1/16w 10uf c217 +5v 16v 100nf c216 r214 10 5 6 7 8 50v c201 100nf ic202 1 2 3 4 pc7 36 pd0 35 pd1 34 33 pd2 32 pd3 pd4 31 30 pd5 rstb 4 v33 644 vsynci lm1881m 28 pb4 27 pb5 26 pb6 25 pb7 pc0 3 pc1 2 pc2 142 pc3 41 pc4 40 pc5 pc6 37 pa1 23 pa2 pa3 22 pa4 21 pa5 20 pa6 19 pa7 18 17 pb0 pb1 16 pb2 15 pb3 14 43 hsynci nc1 38 nc2 39 9 osci 8 osco 10 p30 11 p31 12 p34 p35 13 29 pa0 24 +5v nt68f63l ic501 cvv 5 7 gnd 47k r202 1/16w +14v c205 33pf 50v 1/16w 510 r604 c202 100pf 10nf 50v c219 mo 100nf 16v c104 1.5uh l201 12 13 14 ms_3.3v c100 100uf 16v 2 3 4 5 6 7 8 9 10 11 +14v cn101 slcon14p_1 1 1/16w 10k r504 l600 1.5uh c102 16v 100uf 1 nc 5 vcc y 4 1/16w 100 r607 nc7sz14m5x ic201 a 2 gnd 3 1 2 3 +14v 16v 100nf c204 bzx84c5v1 d201 c103 100uf 16v c200 16v 100uf c510 100nf 7 8 +5v +14v 1/16w r205 100 m24c08-wmn1t ic502 1 2 3 4 5 6 d200 a 1 2 b 3 c +3.3v bzx84c5v1 14 15 16 17 18 19 20 21 22 10 r219 4 5 6 7 8 9 10 11 12 13 cn202 slcon22p_1 1 2 3 sda scl led_b h*v_sync a_h*v_sync h*v_sync sel_mdl ms_irq* key1_in chk_dsub ms_reset* chk_dvi *panel_en *dpms_on bright key2_in ms_scl ms_sda green amber v_sync h_sync led_a ddc_data ddc_clk inv_gnd *lvds_en a_v_sync *bklt_en sog_sync agnd agnd agnd agnd ms_scl ms_sda sog_sync *bklt_en key1_in key2_in *panel_en *dpms_on scl sda bright *bklt_en sel_mdl inv_gnd agnd red+ a_h*v_sync a_v_sync ddc_data ddc_clk agnd blu+ grn+ chk_dsub amber green 13 15 14 10 11 8
sec lt140x1-002 bn07-00004a sa bn68-00187a sec lt150xs-l01 bn07-00009a sb bn68-00187b sec lt150xs-l01-b bn07-00022a sc bn68-00187c sec ltm150xs-l02 bn07-00005a sd bn68-00187d sec lt181e2-132 bn07-00001a se bn68-00187e sec lt150xs-t01 bn07-00010a sf bn68-00187f sec ltm181e3-132 bn07-00019a sg bn68-00187g sec lt170e2-131 bn07-10001d sh bn68-00187h sec lt181e2-131 bn07-10001e sj bn68-00187j sec ltm170e4-l01 bn07-00018a sk bn68-00187k sec ltm240w1-l01 bn07-00015a sl bn68-00187l sec ltm213u3-l01 bn07-00016a sm bn68-00187m sec ltm150xh-l01 bn07-00026a sn bn68-00187w sec ltm150xh-l03 bn07-00027a sp bn68-00187x sec ltm150xs-l01 bn07-00032a sq bn68-00195b dell(zpd) sec ltm181e4-l01 bn07-00034a sr bn68-00195c pva sec ltm170eh-l01 bn07-00036a ss bn68-00195d tn sec ltm170e5-l01 bn07-00037a su bn68-00195e pva sec ltm150xh-l11 bn07-00041a sv bn68-00195g sec ltm213u4-l01 bn07-00039a sw bn68-00195l pva sec ltm150xh-l01(zpd) bn07-00045a sx bn68-00195m zpd sec ltm150xh-l04 bn07-00046a sy bn68-00195n panel sec ltm170w1-l01 bn07-00047a sz bn68-00195p tv panel sec ltm150xh-l06 bn07-00053a ea bn68-00195v tv panel/450cd sony& eos panel sec ltm153w1-l01 bn07-00054a eb bn68-00195w nike model sec ltm170eh-l05 bn07-00055a ec bn68-00195x 17?eh-l05 panel eos proj. sec ltm170e5-l03 bn07-00056a ed bn68-00195y dell 1702fp pro. e4 compatible sec ltm190e1-l01 bn07-00057a ee bn68-00195z dell 1900 fp sec ltm181e5-l01 bn07-00061a ef bn68-00239c 18?narrow bezel gh18ps sec ltm150xp-l01 bn07-00065a eg bn68-00239f amlcd pva panel sec ltm240w1-l02 bn07-00062a eh bn68-00239g 15?wide tv panel toshiba ltm15c419(a) bn07-00002a ta bn68-00187n toshiba ltm15c423(b) bn07-00006a tb bn68-00187p toshiba ltm18c161 bn07-00008a tc bn68-00187u toshiba ltm15c443 bn07-00031a td bn68-00195a toshiba ltm15c458 bn07-00043a te bn68-00195h hannstar hsd150mx41a(a) bn07-00020a na bn68-00187q ttl hannstar hsd150mx12 bn07-00030a nb bn68-00187y lvds torisan tm150xg-22l03(a) bn07-00021a ra bn68-00187r torisan tm150xg-26l06 bn07-00042a rb bn68-00195j torisan tm181sx-76n01 bn07-00048a rc bn68-00195q torisan tm150xg-22l06 bn07-00059a rd bn68-00239a 15?xga tn mode(zpd) torisan tm290wx-71n31 bn07-00063a re bn68-00239d rs24ns (torisan 29?new panel) torisan tm396wx-71n31 bn07-00064a rf bn68-00239e rs24ns (torisan 40?new panel) sharp lq181e1dg11(a) bn07-10001c pa bn68-00187s hitachi tx38d12vc0caa(a) bn07-00003a ha bn68-00187t hitachi tx43dvcocab bn07-00060a hb bn68-00239b 17?sxga pva mode ibm itsx94s bn07-00017a ia bn68-00187v unipac um170e0 bn07-00028a ua bn68-00187z hyundai ht15x13 bn07-00035a da bn68-00195f hyundai ht17e11-200 bn07-00049a db bn68-00195r tn mode acer l170e3 bn07-00044a aa bn68-00195k tn(adt) chimei m170e3-lo1 bn07-00050a ca bn68-00195s tn panel chimei m150x3-l01 bn07-00051a cb bn68-00195t compatible chimei m170e4-l01 bn07-00052a cc bn68-00195u mva panel mo15e* 10-1 confidential maker vendor p/n panel_code panel_abb sticker_code remarks 10 panel description
confidential mo15e* copyright ? 2002 by samsung electronics co., ltd. all rights reserved. this manual may not, in whole or in part, be copied, photocopied, reproduced, translated, or converted to any electronic or machine readable form without prior written permission of samsung electronics co., ltd. mo15e* service manual first edition march 2002. printed in korea. trademarks samsung is a registered trademark and mo15e* and macmaster cable adapter are trademarks of samsung electronics co., ltd. macintosh, centris, quadra, duo dock, and power macintosh are trademarks of apple comprter, inc. all other trademarks are the property of their respective owners. ii
10 panel description 10-2 mo15e* confidential memo
confidential 9 schematic diagrams 9-2 mo15e* 8 10 11 13 14 15
confidential 9- 2 schematic diagram 9 schematic diagrams mo15e* 9-3 config0 : iic_addr 0 0 config1 : iic_addr 1 0 config2 : iic_addr 2 0 config3 : iic_addr 3 1 config4 : 0-iic, 1-spi 0 120ohm 120ohm 120ohm 16v 100uf 120ohm 120ohm 120ohm +5v rc1117st-3.3 2 vout 3 vin tab 4 1 gnd ic602 c341 c346 100uf 16v c342 c345 100pf c343 100pf 15pf 100pf c344 1.5uh 1.5uh l303 1.5uh c327 l302 l300 22uf 16v 1.5uh ms_3.3v 16v 22uf c326 16v l304 c335 100nf 16v 100nf c336 100nf c334 16v 100nf 16v c329 100nf 16v c333c332 16v 100nf100nf 16v c330 c331 16v 4.7nf 16v 100nf c315 100nf c328 4.7nf 4.7nfc311 1.5uh c314 l301 ms_3.3v 100nf 16v 100nf 16v c320 100nf 16v c325c324 100nf c321 16v 100nf c323 100nf 16v c322 0 16v r301 39nf c313 10nf c310 10pf ms_3.3v 22uf 16v c316 c309 100nf c317 16v 22uf 16v r300 c307 100nf c308 16v 1/16w 2.2k 100nf 16v +5v c306 1/16w 10k 16v 22uf c305 22uf 16v c300 100nf 16v r302 c304c303 100nf 16v c302 100nf 16v 100nf c301 16v 10nf r303 c312 kia431af-rtf 10k 1/16w 3 out 1 in 2 gnd ic301 1/16w 1m r322 10k 1/16w r323 1/16w 10k 10k 1/16w 10k 1/16w r321 r319 1/16w 10k r318 r312 10k 1/16w tvclk ic300 xtalo 73 74 xtali 50 vtop r317 155 60 vref 43 38 vga_vsync vga_hsync 39 36 vccd 58 vccar 52 vccag 46 vccab vcca 41 vbot 51 160 138 red_outb_6 red_outb_5 137 136 red_outb_4 56 toutp toutm 57 40 sogi 78 shclk sda 157 158 scs 156 scl rst 133 132 red_outb_1 red_outb_0 131 red_outa_7 109 108 red_outa_6 red_outa_5 107 106 red_outa_4 104 rndar ri 59 72 reserved red_outb_7 139 145 146 pwm0 osd_r red_outa_3 red_outa_2 103 102 red_outa_1 red_outa_0 101 red_inb_7_uv7 31 30 red_inb_6_uv6 red_inb_5_uv5 29 28 red_inb_4_uv4 134 red_outb_3 red_outb_2 osd_fsw 65 66 osd_clk osd_b 69 lcd_vee 143 142 lcd_vdd red_inb_3_uv3 27 26 red_inb_2_uv2 red_inb_1_uv1 25 24 red_inb_0_uv0 rclp 61 pwm1 grn_outa_3 grn_outa_2 lcd_vbl 141 irq 159 grn_outb7 129 128 grn_outb6 grn_outb5 127 126 grn_outb4 124 grn_outb3 67 70 osd_i 68 osd_g 20 grn_inb_5 grn_inb_4 19 18 grn_inb_3 grn_outb2 123 122 grn_outb1 grn_outb0 121 grn_outa_7 99 98 grn_outa_6 grn_outa_5 97 96 grn_outa_4 94 15 154 gpio1 gpio0 153 54 gndag 48 gndab gi 53 gclp 55 93 92 grn_outa_1 grn_outa_0 91 22 grn_inb_7_rtso grn_inb_6 21 33 dtest 35 130 dobvss_4 120 dobvss_3 110 dobvss_2 90 dobvss_1 dobvdd_5 135 dobvdd_4 125 dobvdd_3 grn_inb_2 17 16 grn_inb_1 grn_inb_0 85 disp_vsync 77 disp_hsync 79 76 disp_de dibvss_1 5 dibvss 75 32 dibvdd_2 dibvdd_1 1 dgnd 37 152 34 dvss dvdd 100 dcvss_4 80 dcvss_3 64 dcvss_2 dcvss_1 23 144 dcvdd_4 dcvdd_3 105 dcvdd_2 71 14 dcvdd_1 cz 45 115 dobvdd_2 95 dobvdd_1 113 44 cp config4 151 150 config3 config2 149 148 config1 config0 147 4 cap_vsync cap_hsync 3 2 cap_href dcvss_6 140 dcvss_5 86 blu_outa_4 84 blu_outa_3 blu_outa_2 83 82 blu_outa_1 blu_outa_0 blu_outb_7 119 118 blu_outb_6 blu_outb_5 117 116 blu_outb_4 114 blu_outb_3 blu_outb_2 13 12 blu_inb_6_y6 blu_inb_5_y5 11 10 blu_inb_4_y4 blu_inb_3_y3 9 8 blu_inb_2_y2 112 blu_outb_1 blu_outb_0 111 blu_outa_7 89 88 blu_outa_6 blu_outa_5 87 1 blu_inb_1_y1 7 6 blu_inb_0_y0 bi 47 bclp 49 42 agnd advss 63 62 advdd mascotv 81 blu_inb_7_y7 1 tp1426 tp1425 22pf c337 50v50v 22pf 50v c318 c338 22pf c340 c319 0.01nf 0.01nf x301 q1q0 hc-49/s-smd(12mhz,30ppm) 6 22pf 50v c339 8 7 6 5 4 3 5 4 3 2 1 ra305 8 77 6 5 4 3 2 1 ra303 2 1 ra304 8 7 86 5 4 6 5 4 3 2 1 ra302 8 7 6 5 4 3 2 13 2 1 ra301 75 8 7 r306 ra300 75r304 r307 75 75r305 der(7:0) der(2) der(3) der(4) der(5) der(6) der(7) deg(7) deg(7:0) der(0) der(1) deg(1) deg(2) deg(3) deg(4) deg(5) deg(6) deb(6) deb(7) deb(7:0) deg(0) deb(0) deb(1) deb(2) deb(3) deb(4) deb(5) dhs dclk ms_reset* ms_sda ms_scl agnd agnd den dvs blu+ grn+ v_sync h_sync agnd agnd ms_irq* red+ agnd 1 9 2 12
confidential 9 schematic diagrams 9-4 mo15e* 1 9 12 2
confidential 9- 3 schematic diagram 9 schematic diagrams mo15e* 9-5 place at pin26 47 r405 r406 47 100nf c405 c400 100uf c406 470nf 16v mo 0 c404 100nf r411 15 16 17 18 19 20 21 22 3 4 5 6 7 8 9 10 11 12 13 14 panel_3.3v cn400 slcon22p_1 1 2 r410 47 ms_3.3v 47r409 r404 r403 47 47 r402 47 47r401 mo 16v 470nf c407 l403 1.5uh c401 100uf 1.5uh l400 l401 1.5uh 42 txout3+ 37 38 txout3- 1 vcc vcc1 9 vcc2 26 56 2 txin5 3 txin6 4 txin7 txin8 6 txin9 7 txout0+ 47 48 txout0- txout1+ 45 46 txout1- txout2+ 41 txout2- 54 txin2 22 txin20 23 txin21 24 txin22 25 txin23 txin24 27 28 txin25 30 txin26 50 txin27 txin3 55 txin4 txin1 txin10 8 txin11 10 11 txin12 12 txin13 14 txin14 15 txin15 txin16 16 18 txin17 txin18 19 20 txin19 lvdsgnd2 44 lvdsvcc pllgnd 35 33 pllgnd1 34 pllvcc 32 pwrdwn r_fb 17 txclkin 31 txclkout+ 39 40 txclkout- 51 txin0 52 5 gnd1 gnd2 13 21 gnd3 gnd4 29 gnd5 53 lvdsgnd 49 43 lvdsgnd1 36 r408 ds90c385mtd ic401 r407 47 47 c403 100nf 10nf c402 1.5uh l402 txe0+ txe0- txe1+ txe1- txeclk- dhs dvs den txe2+ txe2- txeclk+ der(7:0) der(0) der(1) der(2) der(3) der(4) der(5) der(6) der(7) deg(7:0) deg(0) deg(1) deg(2) deg(3) deg(4) deg(5) deg(6) deg(7) deb(7:0) deb(0) deb(1) deb(2) deb(3) deb(4) deb(5) deb(6) deb(7) *lvds_en dclk 7 6 5 1 3 4
9 schematic diagrams 9-6 mo15e* confidential 1 3 4 5 6 7
memo 8 wiring diagram 8-2 mo15e* confidential
7 block diagrams 7-2 mo15e* confidential memo
c311 2203-000888 c-ceramic,chip 4.7nf,10%,50v,x7r,tp,1608 c312 2203-000257 c-ceramic,chip 10nf,10%,50v,x7r,tp,1608 c313 2203-000257 c-ceramic,chip 10nf,10%,50v,x7r,tp,1608 c314 2203-000888 c-ceramic,chip 4.7nf,10%,50v,x7r,tp,1608 c315 2203-000888 c-ceramic,chip 4.7nf,10%,50v,x7r,tp,1608 c316 2402-000135 c-al,smd 22uf,20%,16v,gp,tp,5.3x5.3x5.4 c317 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c318 2203-000280 c-ceramic,chip 0.01nf,0.5pf,50v,np0,tp,1608 c319 2203-000280 c-ceramic,chip 0.01nf,0.5pf,50v,np0,tp,1608 c320 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c321 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c322 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c323 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c324 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c325 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c326 2402-000135 c-al,smd 22uf,20%,16v,gp,tp,5.3x5.3x5.4 c327 2402-000135 c-al,smd 22uf,20%,16v,gp,tp,5.3x5.3x5.4 c328 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c329 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c330 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c331 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c332 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c333 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c334 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c335 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c336 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c337 2203-000626 c-ceramic,chip 0.022nf,5%,50v,np0,tp,1608 c338 2203-000626 c-ceramic,chip 0.022nf,5%,50v,np0,tp,1608 c339 2203-000626 c-ceramic,chip 0.022nf,5%,50v,np0,tp,1608 c340 2203-000626 c-ceramic,chip 0.022nf,5%,50v,np0,tp,1608 c341 2203-000236 c-ceramic,chip 0.1nf,5%,50v,np0,tp,1608 c342 2203-000236 c-ceramic,chip 0.1nf,5%,50v,np0,tp,1608 c343 2203-000384 c-ceramic,chip 0.015nf,5%,50v,np0,tp,1608 c344 2203-000236 c-ceramic,chip 0.1nf,5%,50v,np0,tp,1608 c345 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c346 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c400 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c401 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c402 2203-000257 c-ceramic,chip 10nf,10%,50v,x7r,tp,1608 c403 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c404 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c405 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c406 2203-001652 c-ceramic,chip 470nf,+80-20%,16v,y5v,tp,1608 c407 2203-001652 c-ceramic,chip 470nf,+80-20%,16v,y5v,tp,1608 c500 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c501 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c502 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c503 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c504 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c505 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c506 2203-000626 c-ceramic,chip 0.022nf,5%,50v,np0,tp,1608 6 electrical parts list 6-2 mo15e* loc. no. code no. description specification remarks confidential
confidential 6 electrical parts list mo15e* 6-3 c507 2203-000626 c-ceramic,chip 0.022nf,5%,50v,np0,tp,1608 c508 2402-000108 c-al,smd 10uf,20%,16v,wt,tp,4.3x4.3x5.4 c509 2203-001652 c-ceramic,chip 470nf,+80-20%,16v,y5v,tp,1608 c510 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c511 2203-000384 c-ceramic,chip 0.015nf,5%,50v,np0,tp,1608 c512 2203-000384 c-ceramic,chip 0.015nf,5%,50v,np0,tp,1608 c513 2203-001652 c-ceramic,chip 470nf,+80-20%,16v,y5v,tp,1608 c600 2203-000189 c-ceramic,chip 100nf,+80-20%,25v,y5v,tp,1608, c601 2203-000189 c-ceramic,chip 100nf,+80-20%,25v,y5v,tp,1608, c701 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm c702 2203-005005 c-ceramic,chip 100nf,10%,16v,x7r,tp,1608 c703 2203-001652 c-ceramic,chip 470nf,+80-20%,16v,y5v,tp,1608 c704 2203-001652 c-ceramic,chip 470nf,+80-20%,16v,y5v,tp,1608 c705 2203-001652 c-ceramic,chip 470nf,+80-20%,16v,y5v,tp,1608 c706 2402-001042 c-al,smd 100uf,20%,16v,gp,tp,6.6x6.6x5.4mm cn101 3711-000556 connector-header box,12p,1r,1.25mm,smd-a,sn sna cn202 3711-003161 connector-header box,20p,1r,1.25mm,angle,sn sna cn400 3711-003161 connector-header box,20p,1r,1.25mm,angle,sn sna cn600 3711-002049 connector-header box,6p,1r,1.25mm,smd-a,sn sna d100 0402-001098 diode-rectifier sk34,40v,3a,smc,tp d201 0403-000579 diode-zener bzx84c5v1,5.1v,5%,200mw,sot-23 d202 0403-000579 diode-zener bzx84c5v1,5.1v,5%,200mw,sot-23 d203 0401-001056 diode-switching mmbd4148se,75v,200ma,sot-23,tp d204 0401-001056 diode-switching mmbd4148se,75v,200ma,sot-23,tp d205 0401-001056 diode-switching mmbd4148se,75v,200ma,sot-23,tp ft701 3301-001145 core-ferrite bead ab,4.5x1.6x1.6mm,-,- sna ic100 1203-001447 ic-posi.fixed reg. 2596,to-263,5p,-,plastic,3.135 ic200 0403-001435 diode-zener qzx363c5v6,5.32-5.88,200mw,sot-363,tp ic201 0801-002478 ic-cmos logic 7sz14,schmitt trigger,sot23,5p,63mil,single,tr,plastic,-,-,6v,-40to+85c,200mw,-0 ic202 1204-001551 ic-video system gs1881,soic,8p,150mil,plastic,13.2v,-,0to+70c,tp,video sync separator ic300 0904-001655 ic-graphic cont. mascotv,24bit,pqfp,160p,28x28mm,160mhz,tr,cmos,plastic,3.3v,2w,0to+70c,-,-,-,-,- ic301 1203-001538 ic-posi.adjust reg. 431,sot-89,3p,-,plastic,2.47/3 ic401 1205-002174 ic-transmitter nt7181,tssop,56p,236mil,plastic,3.45v,-,0to+70c,tp,nt7181 ic500 1203-001488 ic-posi.fixed reg. 7805,t0-252,3p,-,plastic,4.8/5 ic501 0903-001266 ic-microcontroller nt68f63,8bit,plcc,44p,653mil,12mhz,st,cmos,plastic,5v,-,-0to+70c,256b,4kb,-,-,mc ic502 1103-001023 ic-eeprom 524c80d81,1028x8bit,sop,8p,150mil,10ms,5v,10%,plastic,0to+70c,110ua,cmos,tp ic601 0403-001435 diode-zener qzx363c5v6,5.32-5.88,200mw,sot-363,tp ic602 1203-000490 ic-switch vol. reg. 1117,sot-223,3p,-,plastic,3.235/3.365v,-,0to+125c,800ma,1.224/1.264v,tp l101 bn27-20001a coil-choke -,53.0uh,20%,dr10*5,-,-,-,-,0.18ohm,-,-,-,tray l201 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l300 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l301 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l302 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l303 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l304 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l400 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l401 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l402 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l403 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l600 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm l601 2703-001334 inductor-smd 1.5uh,10%,2x1.25x0.85mm loc. no. code no. description specification remarks
mp1.0 bn41-00161a pcb main mo15es,fr4,4l,120*100*1.0,mo15es q600 0501-000342 tr-small signal ksc1623-y,npn,200mw,sot-23,tp,135-270 q601 0501-000342 tr-small signal ksc1623-y,npn,200mw,sot-23,tp,135-270 q701 0501-000342 tr-small signal ksc1623-y,npn,200mw,sot-23,tp,135-270 r100 2007-000084 r-chip 4.7kohm,5%,1/16w,da,tp,1608 r101 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r102 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r200 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r201 2007-000097 r-chip 47kohm,5%,1/16w,da,tp,1608 r202 2007-000097 r-chip 47kohm,5%,1/16w,da,tp,1608 r203 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r204 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r205 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r206 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r207 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r208 2007-000309 r-chip 10ohm,5%,1/16w,da,tp,1608 r209 2007-000113 r-chip 33ohm,5%,1/16w,da,tp,1608 r210 2007-001167 r-chip 75ohm,5%,1/16w,da,tp,1608 r211 2007-000309 r-chip 10ohm,5%,1/16w,da,tp,1608 r212 2007-000113 r-chip 33ohm,5%,1/16w,da,tp,1608 r213 2007-001167 r-chip 75ohm,5%,1/16w,da,tp,1608 r214 2007-000309 r-chip 10ohm,5%,1/16w,da,tp,1608 r215 2007-000113 r-chip 33ohm,5%,1/16w,da,tp,1608 r216 2007-001167 r-chip 75ohm,5%,1/16w,da,tp,1608 r217 2007-000070 r-chip 0ohm,5%,1/16w,da,tp,1608 r218 2007-001114 r-chip 680kohm,5%,1/16w,da,tp,1608 r219 2007-000309 r-chip 10ohm,5%,1/16w,da,tp,1608 r220 2007-000084 r-chip 4.7kohm,5%,1/16w,da,tp,1608 r300 2007-000124 r-chip 2.2kohm,5%,1/16w,da,tp,1608 r301 2007-000070 r-chip 0ohm,5%,1/16w,da,tp,1608 r302 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r303 2007-000109 r-chip 1mohm,5%,1/16w,da,tp,1608 r304 2007-001167 r-chip 75ohm,5%,1/16w,da,tp,1608 r305 2007-001167 r-chip 75ohm,5%,1/16w,da,tp,1608 r306 2007-001167 r-chip 75ohm,5%,1/16w,da,tp,1608 r307 2007-001167 r-chip 75ohm,5%,1/16w,da,tp,1608 r312 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r317 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r318 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r319 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r321 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r322 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r323 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r401 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 r402 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 r403 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 r404 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 r405 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 r406 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 r407 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 r408 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 6 electrical parts list 6-4 mo15e* loc. no. code no. description specification remarks confidential
confidential 6 electrical parts list mo15e* 6-5 r409 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 r410 2007-000072 r-chip 47ohm,5%,1/16w,da,tp,1608 r411 2007-000070 r-chip 0ohm,5%,1/16w,da,tp,1608 r500 2007-000077 r-chip 470ohm,5%,1/16w,da,tp,1608 r501 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r502 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r503 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r504 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 r505 2007-000109 r-chip 1mohm,5%,1/16w,da,tp,1608 r506 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r507 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r508 2007-000458 r-chip 18kohm,5%,1/16w,da,tp,1608 r509 2007-000458 r-chip 18kohm,5%,1/16w,da,tp,1608 r511 2007-000084 r-chip 4.7kohm,5%,1/16w,da,tp,1608 r512 2007-000084 r-chip 4.7kohm,5%,1/16w,da,tp,1608 r513 2007-000084 r-chip 4.7kohm,5%,1/16w,da,tp,1608 r514 2007-000070 r-chip 0ohm,5%,1/16w,da,tp,1608 r515 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r516 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r517 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r518 2007-000078 r-chip 1kohm,5%,1/16w,da,tp,1608 r519 2007-000084 r-chip 4.7kohm,5%,1/16w,da,tp,1608 r520 2007-000084 r-chip 4.7kohm,5%,1/16w,da,tp,1608 r521 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r523 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r524 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r525 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r526 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r527 2007-000070 r-chip 0ohm,5%,1/16w,da,tp,1608 r604 2007-001002 r-chip 510ohm,5%,1/16w,da,tp,1608 r605 2007-001002 r-chip 510ohm,5%,1/16w,da,tp,1608 r606 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r607 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r700 2007-000084 r-chip 4.7kohm,5%,1/16w,da,tp,1608 r701 2007-000309 r-chip 10ohm,5%,1/16w,da,tp,1608 r702 2007-000074 r-chip 100ohm,5%,1/16w,da,tp,1608 r703 2007-000090 r-chip 10kohm,5%,1/16w,da,tp,1608 ra300 2011-001410 r-network 120ohm,5%,1/16w,l,chip,8p,tp ra301 2011-001410 r-network 120ohm,5%,1/16w,l,chip,8p,tp ra302 2011-001410 r-network 120ohm,5%,1/16w,l,chip,8p,tp ra303 2011-001410 r-network 120ohm,5%,1/16w,l,chip,8p,tp ra304 2011-001410 r-network 120ohm,5%,1/16w,l,chip,8p,tp ra305 2011-001410 r-network 120ohm,5%,1/16w,l,chip,8p,tp x301 2801-003773 crystal-smd 12mhz,30ppm,28-aan,20pf,50ohm,tp x501 2801-003773 crystal-smd 12mhz,30ppm,28-aan,20pf,50ohm,tp loc. no. code no. description specification remarks
6 electrical parts list 6-6 mo15e* confidential - bn90-00304a assy cover front mo15ps cis bn90-00053b assy cover front mo15ps,abs hb,bk07,analog sna - bn90-00305a assy cover rear mo15ps cis bn90-00054b assy rear mo15es,abs hb bk07 - bn90-00306a assy stand mo15ps cis bn90-00056b assy stand mo15ps,abs hb,bk07,analog - bn91-00301c assy misc-adaptor dv18ms sna cis bn44-00058a adaptor pscv420106a(ad-4214n,gh17ps ,100 to 240 vac,47 - 63 hz,+14vdc,3a,-,42w,ac-dc,0 t - bn91-00311b assy lcd gd15ns,-,-,- sna cis bn07-00043a lcd ltm15c458,gh15ls,6bit_frc,331.6*254.7*12.5,16.1m,60,0.297*0.297,0~40,3.3,toshiba - bn91-00346a assy chassis mo15es - bn91-00350a assy shield mo15es sna cis bn90-00055a assy shield-pcb mo15ps,-,secc,t0.5,-,-,-,- sna - bn92-00404a assy p/material mo15ps sna loc. no. code no. description specification remarks 6-2 others
5 exploded view & parts list 5-2 mo15e* memo confidential
does the pulse appear at pin 8 of ic501? confidential 4 troubleshooting 4-2 mo15e* 4-2 no video power indicator is green. replace x501 or check its related circuit. no does the clock pulse appear at pin 78 of ic300? does the h-sync pulse appear at pin 38, 39 of ic300? check r304, 305, 306 and 307. replace ic401 or check its related circuit. no do the sync pulses appear at pin 27, 28, 30 and 31 of ic401? yes yes no no yes yes replace x301 or check its related circuit. no no 1 2 does the clock pulse appear at pin 73 of ic300? 9 12 8 do the pulses appear at pin 43, 44 of ic501? replace ic202(sog) or check r207 and pin 13, 15, 17, 19 of cn202. 10 13 14 15 1 3 4 5 11 do the waveforms appear at pins 39 and 40 of ic401? replace lcd panel. yes replace ic300. yes no replace ic501 or check its related circuit. yes 6 7
4 troubleshooting mo15e* 4-3 confidential 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 waveforms
4 troubleshooting 4-4 mo15e* confidential 4-3 no osd there is video but no osd. while pushing a front control button, does any pulse appear at pin 16, 17 of ic501? press exit key for more than 5 seconds to do the factory preset. no do the pulses appear at pin2 and pin3 of cn600 while pushing a front control button? replace ic300 and check its related circuit. yes yes replace ic501 or check its related circuit. replace the key function pba. no
3 disassembly and reassembly 3-2 mo15e* confidential 4. remove 2 flat head screws on the hinge mounting. do not remove the screw for cable clamp. 5. disconnect the stand cable from socket and remove stand assembly. 6. remove 2 screws of cover rear. 7. turn the monitor for front-side up. 8. remove the cover front by fulling the center area of bezel and side area in sequence. if the side area is not loosed easily, open the snap using ? driver at the corner of slot of cover rear.
3 disassembly and reassembly mo15e* 3-3 confidential 9. remove the 4 screws of panel. 10. turn the monitor for face down and open the cover rear from top area. 11. disconnect the function cable from the connector of main board. 12. remove the 3 screws of shield.
confidential 3 disassembly and reassembly 3-4 mo15e* 1. after confirm there is nothing on the disk turn the lcd module over and put it on a flat desk set to the ground. 3-2 replacement order of lamp assemblies 2. remove the screw and slide the lamp unit. 3. please take out the lamp unit from the lcd module.
confidential 3 disassembly and reassembly mo15e* 3-5 4. please fix the new lamp units on the lcd module : opposite process 2 and 3 * replacement of lamp unit should be done at the power off state and recommanded clean bench condition. 3-3 reassembly reassembly procedures are in the reverse order of disassembly procedures.
confidential memo 3 disassembly and reassembly 3-6 mo15e*
confidential 2 product specifications 2-2 mo15e* 2-2 pin assignments sync type pin no. 15-pin signal cable connector separate composite sync-on-green 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 red green blue gnd gnd (ddc return) gnd-r gnd-g gnd-b no connection gnd-sync/self test gnd ddc data h-sync v-sync ddc data red green blue gnd gnd (ddc return) gnd-r gnd-g gnd-b no connection gnd-sync/self test gnd ddc data h/v-sync not used ddc data red green + h/v sync blue gnd gnd (ddc return) gnd-r gnd-g gnd-b not used gnd-sync/self test gnd ddc data not used not used ddc data
confidential 31.469 31.778 3.813 1.589 26.058 0.318 70.086 14.268 0.064 1.716 11.504 0.985 25.175 positive negative separate fh (khz) a ?ec b ?ec c ?ec d ?ec e ?ec fv (hz) o msec p msec q msec r msec s msec clock frequency (mhz) polarity h.sync v.sync remark ibm 2 product specifications mo15e* 2-3 qrs p o video sync sync horizontal vertical cde p o b a video sync sync separate sync 2-3 timing chart this section of the service manual describes the timing that the computer industry recognizes as standard for computer-generated video signals. c d a o e b p video sync sync video q r s a : line time total b : horizontal sync width o : frame time total p : vertical sync width c : back porch d : active time q : back porch r : active time e : front porch s : front porch vga3/60 hz 640 x 480 640/72 hz 640 x 480 640/75 hz 640 x 480 800/56 hz 800 x 600 800/60 hz 800 x 600 vga1/70 hz 640 x 350 vga2/70 hz 720 x 400 table 2-1 timing chart 31.469 31.777 3.813 1.589 26.058 0.318 70.087 14.268 0.064 0.858 13.155 0.191 28.322 negative positive separate 31.469 31.778 3.813 1.589 26.058 0.318 59.940 16.683 0.064 0.794 15.761 0.064 25.175 negative negative separate 37.861 26.413 1.270 3.810 20.825 0.508 72.809 13.735 0.079 0.528 13.100 0.026 31.500 negative negative separate 37.500 26.667 2.032 3.810 20.317 0.508 75.000 13.333 0.080 0.427 12.800 0.027 31.500 negative negative separate 35.156 28.444 2.000 3.556 22.222 0.667 56.250 17.778 0.057 0.626 17.067 0.028 36.000 positive negative separate 37.879 26.400 3.200 2.200 20.000 1.000 60.317 16.579 0.106 0.607 15.840 0.026 40.000 positive positive separate mode vesa timing
confidential 2 product specifications 2-4 mo15e* fh (khz) a ?ec b ?ec c ?ec d ?ec e ?ec fv (hz) o msec p msec q msec r msec s msec clock frequency (mhz) polarity h.sync v.sync remark vesa 800/72 hz 800 x 600 800/75 hz 800 x 600 640/67 hz 640 x 480 832/75 hz 832 x 624 table 2-1 timing chart continued 48.077 20.800 2.400 1.280 16.000 1.120 72.188 13.853 0.125 0.478 12.480 0.770 50.000 positive positive separate 46.875 21.333 1.616 3.232 16.162 0.323 75.000 13.333 0.064 0.448 12.800 0.021 49.500 positive positive separate 35.000 28.571 2.116 3.175 21.164 2.116 66.667 15.000 0.086 1.114 13.714 0.086 30.240 negative negative separate 49.726 20.110 1.117 3.910 14.524 0.559 74.551 13.414 0.060 0.784 12.549 0.020 57.284 negative negative separate mode mac timing qrs p o video sync sync horizontal vertical cde p o b a video sync sync separate sync c d a o e b p video sync sync video q r s a : line time total b : horizontal sync width o : frame time total p : vertical sync width c : back porch d : active time q : back porch r : active time e : front porch s : front porch 1024/70hz 1024x768 56.476 17.707 1.813 1.920 13.653 0.320 70.069 14.272 0.106 0.513 13.599 0.053 75.000 negative negative separate 1024/75hz 1024x768 60.023 16.660 1.219 2.235 13.003 0.203 75.029 13.328 0.050 0.466 12.795 0.017 78.750 positive positive separate 1024/60hz 1024x768 48.363 20.677 2.092 2.462 15.754 0.369 60.004 16.666 0.124 0.600 15.880 0.062 65.000 negative negative separate
1-2-1 general servicing precautions 1. always unplug the unit? ac power cord from the ac power source and disconnect the dc power jack before attempting to: (a) remove or reinstall any component or assembly, (b) disconnect pcb plugs or connectors, (c) connect a test component in parallel with an electrolytic capacitor. 2. some components are raised above the printed circuit board for safety. an insulation tube or tape is sometimes used. the internal wiring is sometimes clamped to prevent contact with thermally hot components. reinstall all such elements to their original position. 3. after servicing, always check that the screws, components and wiring have been correctly reinstalled. make sure that the area around the serviced part has not been damaged. 1. immediately before handling any semiconductor components or assemblies, drain the electrostatic charge from your body by touching a known earth ground. alternatively, wear a discharging wrist- strap device. to avoid a shock hazard, be sure to remove the wrist strap before applying power to the monitor. 2. after removing an esd-equipped assembly, place it on a conductive surface such as aluminum foil to prevent accumulation of an electrostatic charge. 3. do not use freon-propelled chemicals. these can generate electrical charges sufficient to damage esds. 4. use only a grounded-tip soldering iron to solder or desolder esds. 5. use only an anti-static solder removal device. some solder removal devices not classified as ?nti-static can generate electrical charges sufficient to damage esds. 4. check the insulation between the blades of the ac plug and accessible conductive parts (examples: metal panels, input terminals and earphone jacks). 5. insulation checking procedure: disconnect the power cord from the ac source and turn the power switch on. connect an insulation resistance meter (500 v) to the blades of the ac plug. the insulation resistance between each blade of the ac plug and accessible conductive parts (see above) should be greater than 1 megohm. 6. always connect a test instrument? ground lead to the instrument chassis ground before connecting the positive lead; always remove the instrument? ground lead last. 6. do not remove a replacement esd from its protective package until you are ready to install it. most replacement esds are packaged with leads that are electrically shorted together by conductive foam, aluminum foil or other conductive materials. 7. immediately before removing the protective material from the leads of a replacement esd, touch the protective material to the chassis or circuit assembly into which the device will be installed. caution: be sure no power is applied to the chassis or circuit and observe all other safety precautions. 8. minimize body motions when handling unpackaged replacement esds. motions such as brushing clothes together, or lifting your foot from a carpeted floor can generate enough static electricity to damage an esd. 1 precautions 1-2 mo15e* confidential 1-3 electrostatically sensitive devices (esd) precautions some semiconductor (solid state) devices can be easily damaged by static electricity. such components are commonly called electrostatically sensitive devices (esd). examples of typical esd devices are integrated circuits and some field- effect transistors. the following techniques will reduce the incidence of component damage caused by static electricity. 1-2 servicing precautions warning: an electrolytic capacitor installed with the wrong polarity might explode. caution: before servicing units covered by this service manual, read and follow the safety precautions section of this manual. note: if unforeseen circumstances create conflict between the following servicing precautions and any of the safety precautions, always follow the safety precautions.
samsung electronics co.,ltd. 416, maetan-3dong, paldal-gu, suwon city, kyungki-do, korea. printed in korea p/n : bn81-00034c-00 http://www.samsungmonitor.com (syncmaster worldwide) http://www.samsung-monitor.com (syncmaster usa) http://www.sec.co.kr/monitor (korea)

▲Up To Search▲

Price & Availability of MO15ETFT-LCD

	To Download MO15ETFT-LCD Datasheet File
If you can't view the Datasheet, Please click here to try to view without PDF Reader .